BATAKO GREEN MATERIAL

I Gede Yohan Kafrain; Hence Roring; Fenny Moniaga

doi:10.31869/rtj.v7i1.4986

BATAKO GREEN MATERIAL

I Gede Yohan Kafrain, Hence Roring, Fenny Moniaga

Sari

In recent years, there has been a lot of development of wall materials derived from waste, such as husk ash waste, plastic bottle waste, plastic ore waste and fly ash waste. The aim of this research is to make bricks from plastic waste and fly ash waste but not using cement as a binder but using an alkali activator. By not using cement and using fly ash waste and plastic waste, this will reduce environmental pollution both due to cement production and plastic waste which has become a global problem. In this research, bricks were made by mixing plastic, fly ash and alkali activator as a binding agent. The mixture variations used are the ratio of plastic and fly ash with plastic content of 50%, 30% and 20%. In this research, the compressive strength of green material brick concrete was found to be 49.46 kg/cm², 106.35 kg/cm², and 125.29 kg/cm² respectively. The weight of the green material bricks is 1.326 kg/cm3, 1.482 kg/cm³ and 1.502 kg/cm³. The water absorption of green material bricks is 8.29%, 6.49% and 5.36%. Based on SNI 03-0349-1989 green material bricks with a plastic content of 50% are included in quality III solid bricks, while those with plastic content of 30% and 20% are included in quality I solid bricks

Keywords: Brick, Plastic, Fly Ash, Green Material

Teks Lengkap:

PDF

Referensi

Arnold Phengkarsa, Hendra S. Wibawa, Djwantoro Hardijito, (2019), Pembuatan Batako Dengan Memanfaatkan Campuran Fly Ash dan Lumpur Sidoarjo Dengan Kadar Yang Tinggi, Dimensi Pratama Teknik Sipil, Issue:2, Vol.3, pp.1-8.

Aprilia Rizky Triyanti, (2017), Studi Pemanfaatan Fly Ash dan Limbah Sandblasting (Silica Fume) Pada Binder Geopolimer, Skripsi, Jurusan Bangunan Gedung, Program Studi Diploma IV Teknik Sipil Lanjut Jenjang, Institut Teknologi Sepuluh Nopember, Surabaya.

Badan Standarisasi Nasional, (1989), Standar Nasional Indonesia Nomor 03-0349 Tahun 1989 Tentang Bata Beton Untuk Pasangan Dinding, Jakarta.

Badan Standarisasi Nasional, (2002), Standar Nasional Indonesia Nomor 03-3449-2002, Tata Cara Rencana Pembuatan Campuran Beton Ringan dengan Agregat Ringan, Jakarta.

Badan Standarisasi Nasional, (2011), Standar Nasional Indonesia Nomor 1974 Tahun 2011 Tentang Cara Uji Kuat Tekan Beton Dengan Benda Uji Silinder, Jakarta.

Benny Joseph, Arya Lakshmi A, Srath K.T, Sirajudeen C.H, Vyshnavu M. (2013), Green Bricks For Masonry Structures, CUSAT National Conference, India, 13-15 Desember 2013.

Filia Eunike Sofia Paat, Steenie E. Wallah, Reky S. Windah, (2014), Kuat Tarik Lentur Beton Geopolymer Berbasis Abu Terbang (Fly Ash), Jurnal Sipil Statik. Issue:2, Vol.7, pp.337-343.

Irfan Majid Fadholi, (2014), Konduktivitas Dan Ketahanan Api Batako Papercrete Dengan 25% Fly Ash Menggantikan Berat Semen Sebagai Material Dinding Bangunan, Skripsi, Jurusan Teknik Sipil, Program Studi Teknik Sipil, Universitas Islam Indonesia, Yogyakarta.

Juan Satria, Agung Sugiarto, Antoni, Djwantoro Hardjito, (2016), karakteristik beton geopolimer berdasarkan variasi waktu pengambilan fly ash, Dimensi Pratama Teknik Sipil, Issue:1, Vol.5, pp.1-8.

Kusdiyono, Supriyadi, Moch. Tri Rochadi, Herry Ludiro W, (2018), Pengaruh Variasi Penambahan Limbah Plastik Terhadap Kekuatan Tekan Batako Dalam Upaya Pemanfaatan Limbah, Jurnal Wahana Teknik Sipil. Issue;23, Vol.2, pp.64-76.

Lailan Ni`mah, Isna Syauqiah, Agus Mirwan, Doni Rahmat Wicakso, Hesti Wijayanti, (2019), Batako Dari Limbah Botol Plastik: Tinjauan Kuat Tekan, Al Ulum Sains dan Teknologi, Issu: 1, Vol.5, pp.26-29.

Mashuri, Andi Arham Adam, Rahmatag Rahman, Arief Setiawan, (2012), Penggunaan Abu Terbang Batu Bara Pada Pembuatan Batako di Kota Palu, Majalah Ilmiah Mektek, Issue:XIV Vol.3, pp.85-92.

Rudolvo Wenno, Steenie E. Wallah, Ronny Pandaleke, (2014), Kuat tekan mortar dengan menggunakan abu terbang (fly ash) asal pltu amurang sebagai substitusi parsial semen, Jurnal Sipil Statik, Issue:5, Vol.2, pp.252-259.

Yohan, Hence, Fenny, (2020), Batako Interlock Material Komposit, Indonesian Journal of Fundamental Sciences, Issu: 2, Vol.6, pp.113-126.

Zhandy, (2012), Pengaruh Bahan Tambah Fly Ash Terhadap Karakteristik Batako Menggunakan Teknologi Manual Blok Getar. Skripsi, Jurusan Teknik Sipil, Program Studi Strata I Teknik, Universitas Jember, Jember.

DOI: https://doi.org/10.31869/rtj.v7i1.4986